|
3-1-grafik-tekushhego-obsluzhivaniya.html
3.1. Schedule of routine maintenanceThe intervals of routine maintenance of the car stipulated in the present section are calculated on independent performance by the owner of the vehicle of all necessary procedures. Duration of intervals was defined proceeding from the assumption that the car is operated in the daily mode. Constantly to support the vehicle in dive of a form, some of procedures for desire of the owner can be carried out slightly more often. Authors of the present manual are sure that receiving the maximum return from the power unit of the car and its other knots and systems can achieve only on condition of a conscientious attitude of the owner to care of the vehicle. It is worth to remember as well about need of maintenance of a trade dress of the car on a case of its resale.
At operation of the car in the conditions of strongly dusty area, an intense city cycle (frequent short trips), and also at frequent towage of the trailer, intervals of performing procedures of routine maintenance have to be, whenever possible, reduced to a minimum.
Arrangement of mouths and some elements of the car
Servicing of the new vehicle has to be made on the company HUNDRED companies manufacturers of the car in order to avoid violation of factory guarantee certificates.
|
|
After passing of 96 000 km of a run (48 months later) the cycle Graphics is repeated. |
Through each 12 000 km of a run or times in 6 months (that will come earlier)
You make replacement of motive oil and an oil filter *.
You make rotation of wheels (only on a run).
Check a condition of the saloon filter.
Through each 24 000 km of a run or times in 12 months (that will come earlier)
Check a condition of brake blocks / boots and disks / барабанов*.
Check a condition of brake lines and driving cables.
Check for existence of signs of development of leak of lubricant liquids cases of AT, the transfer case and differential (except LSD).
|
|
At towage the car trailer / equipment the "Caravan" van, operation of the car in cross-country conditions, besides check of the corresponding components on leaks it is also necessary to make replacement of lubricant liquids through each 48 000 km of a run or times in 24 months. |
Check differential of limited sliding (LSD) for existence of signs of development of leak of gearbox oil.
|
|
At towage the car trailer / equipment the "Caravan" van, operation of the car in cross-country conditions gearbox oil of differential of LSD has to be replaced through each 24 000 km of a run or times a year. |
Check a condition of protective covers of power shafts *.
You make greasing of driveshafts *.
|
|
At commission of water crossings greasing of driveshafts has to be made on a daily basis. |
Check a condition of lubricant of stupichny bearings of forward wheels.
You make replacement a condition of the saloon filter.
Check a condition of vacuum hoses of a tempostat (ASCD).
Through each 48 000 km of a run or times in 24 months (that will come earlier)
Check a condition of belts of the drive of auxiliary units.
You make replacement of the filtering air cleaner element (only on a run).
|
|
At operation of the car in the conditions of strongly dusty area replacement of the filtering element of the air cleaner should be made more often. |
Check a condition of lines of system of catching of fuel evaporations (EVAP).
Check a condition of fuel lines.
You make replacement of gearbox oil of differential of limited sliding (LSD).
Check a condition of components of a suspension bracket, the steering drive and the transmission line **.
You make stuffing by lubricant of stupichny bearings of forward wheels.
|
|
At frequent commission of water crossings restuffing of wheel bearings has to be made twice more often. |
Check a condition of components of system of production of the fulfilled gases **.
Through each 96 000 km of a run or times in 48 months (that will come earlier)
You make replacement of cooling liquid of the engine.
|
|
After passing of the first 96 000 km of a run (after the first 2 years of operation) replacement of cooling liquid should be made twice more often. |
You make replacement of spark plugs (only on a run).
Through each 168 000 km of a run
You make replacement of a belt of the GRM drive
In 10 years from the moment of release of the car
Make check of a condition of the SRS elements.
|
|
Replacement of the fuel filter should be made at decrease in the power developed by the engine when acceleration performance of the car considerably decreases. |
|
|
* At intensive operation of the car implementation of the procedures marked with one asterisk should be made twice more often. |
|
|
** At intensive operation of the car implementation of the procedures marked with one asterisk should be made four times more often. |
Intensive are understood as the following conditions:
- Often repeating short trips on distance less than 8 km;
- Often repeating short trips on distance less than 16 km at negative air temperatures;
- The movement in hot weather in the conditions of an intense city cycle;
- Passing of long distances with low turns and long operation of the engine on single turns (a taxi, police, address delivery, etc.);
- The movement in strongly dusty area;
- The movement on dirt or the salted roadbed;
- Frequent towage of the trailer, equipment of the "Caravan" van.
Features of service of the car at operation in cross-country conditions
At frequent use of the car for passing through deep sandy, mud or water barriers the thicket should check a condition of such components as:
- Brake blocks / boots and disks / drums;
- Brake tubes and hoses;
- Wheel bearings (lubricant);
- Differential, transmission and transfer case (lubricant liquids);
- Steering drive;
- Driveshafts and power shafts of forward wheels;
- The filtering air cleaner element.
Explanations on performing procedures of routine maintenance
|
|
More detailed information is stated below in appropriate sections of the present Chapter. |
Service of elements of systems of decrease in toxicity of the fulfilled gases:
Driving belts
Check a state and effort of a tension of the corresponding driving belts. At identification of cracks, attritions and other damages make replacement, in case of need adjust a tension.
The filtering air cleaner element
In normal service conditions replacement of the filtering element of the air cleaner has to be made according to the schedule of routine maintenance, however at strong dust content of the area it should be carried out more often (see notes above).
Lines of a vaporizing path of EVAP
Check reliability of delay in nipple connections. In case of identification of signs of development of leaks replace the corresponding components.
Fuel lines
Check reliability of delay in nipple connections. In case of identification of signs of development of leaks replace the corresponding components.
Cooling liquid of the engine
At intensive operation of the car replacement of cooling liquid should be made more often than it is stipulated by the Schedule of routine maintenance.
Motive oil and oil filter
Replacement of oil and oil filter should be made strictly according to the Schedule of routine maintenance. As replaceable it is necessary to use the No. 15208 31U00 filter according to the Infiniti catalog.
Spark plugs
As replaceable it is necessary to use candles of the corresponding type with platinum electrodes.
Gas-distributing belt
The gear gas-distributing belt is used for the drive of camshafts. You make replacement of a belt strictly according to the Schedule of routine maintenance.
|
|
Upon purchase of the car which was in operation it will be reasonable to replace a belt, without relying on the data issued by the previous owner. |
Service of elements of the chassis and body
Brake lines and driving cables
Attentively examine all lines of a brake path (including vacuum hoses of the servo-driver of the brake amplifier) on existence of cracks, dents, cuts, attritions, and other signs of mechanical damage. Check serviceability of functioning of cables of the drive of the parking brake.
Brake blocks / boots and disks / drums
Estimate degree of wear of the listed components, in case of need make replacement. At intensive operation of the car check of a condition of these components should be made more often than it is stipulated by the main Schedule of routine maintenance.
The greasing AT liquids, the transfer case and differential
Visually check cases of the listed components for existence of signs of development of leak of the greasing liquids. In case of need make the corresponding corrections and adjustments. At intensive operation of the car check of a condition of these knots should be made more often than it is stipulated by the main Schedule of routine maintenance.
Components of a suspension bracket, steering drive and transmission line
Attentively examine components of a suspension bracket, the steering drive and the transmission line on existence of mechanical damages, deformations and signs of development of leak of lubricant. Check a condition of all knots of a joint of the listed components. At intensive operation of the car check of a condition of these knots should be made more often than it is stipulated by the main Schedule of routine maintenance.
Driveshafts
Check driveshafts for existence of mechanical damages and signs of development of leak of lubricant. Estimate a side play of hinged knots.
When replacing lubricant you make its stuffing via special lubricant unions. Act strictly according to the Schedule of routine maintenance.
Stupichny bearings of forward wheels
Check of a condition of lubricant and restuffing of bearings should be made strictly according to the Schedule of routine maintenance.
Elements of system of production of the fulfilled gases
Visually estimate a condition of tubular sections of system, and suspensions of their support. In case of identification of signs of development of leak of the fulfilled gases or mechanical damages of components replace the corresponding sections of system.
Saloon filter
Replacement of the saloon filter should be made strictly according to the Schedule of routine maintenance. Are among signs of violation of passability of the filtering element: decrease in intensity of air supply via deflectors of systems of ventilation / heating / conditioning of salon, and also fogging of glasses even at the included К/В system.
SRS elements
Performing procedures of service of the SRS elements should be charged to specialists of car service.
Vacuum hoses of the operating path of a tempostat (ASCD)
Check a condition of the vacuum hose connecting the actuation mechanism of a tempostat to the pump ASCD.
|